Product ID:037 WET R DRI ROOF CEMENT
MSDS Date:05/01/1993
FSC:8030
NIIN:00F024959
MSDS Number: BWHPG

GARDNER ASPHALT CORP

4161 7TH AVE
TAMPA, FL 33675-5449
US

Emergency Phone: 813-248-2101/800-237-1155

Info Phone: 813-248-2101/800-237-1155

Cage: 0VZ30

GARDNER ASPHALT CORP

5449 TAMPA, FL 33605 US

Telephone: 800-237-1155/813-248-2101

Cage: 0VZ30

CELLULOSE

CAS: 9004-34-6

RTECS: FJ5691460

Fraction By Weight: <5%

OSHA PEL 5 MG/CUM

ACGIH TLV: 10 MG/CUM (DUST)

INORGANIC FILLER

Fraction By Weight: <45%

ACGIH TLV: 10 MG/CUM

ISOPARAFFINIC HYDROCARBONS (NAPHTHA PETROLEUM),

CAS: 64742-48-9

Fraction By Weight: <20%

ACGIH TLV: 100 PPM

ASPHALT FUMES, ASPHALT, CUTBACK ASPHALT

CAS: 8052-42-4

RTECS: CI9900000

Fraction By Weight: <40%

ACGIH TLV: 5 MG/CUM

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: IRRITATION &
DERMATITIS. MINUTE AMOUNTS ASPIRATED INTO LUNGS DURING INGESTION
CAUSE MILD-SEVERE PULMONARY INJURY/POSSIBLY DEATH.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN/NERVOUS SYSTEM DAMAGE. PETROLEUM SOLVENTS & ASPHALT
COMPOUNDS-SEVERE EYE IRRITATION, (SEE SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION & DEFATTING. PETROLEUM SOLVENTS &
ASPHALT COMPOUNDS-REDNESS, TEARING, BLURRED VISION, IRRITATION,
DEFATTING, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE,
UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:PRE-EXISTING CNS DISEASE, SKIN
DISORDERS, CHRONIC RESPIRATORY DISEASE.

First Aid:EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS. SKIN:
THOROUGHLY WASH EXPOSED AREA W/SOAP & WATER. INHALATION: REMOVE TO
FRESH AIR. GIVE CPR/OXYGEN IF NEEDED. KEEP WARM & QUIET. INGESTION:
DON'T IND UCE VOMITING. ASPIRATION HAZARD. OBTAINMEDICAL ATTENTION
IN ALL CASES. NOTE TO PHYSICIAN: PERFORM GASTRIC LAVAGE
IAW/PROCEDURES FOR INGESTION OF PETROLEUM PRODUCTS.

Flash Point Method:TCC
Flash Point:103F
Lower Limits: 0.9
Upper Limits: 6
Extinguishing Media:DRY CHEMICAL, CO2, UNIVERSAL TYPE FOAM, WATER FOG
ARE EFFECTIVE BUT MAY CAUSE FROTHING. DON'T USE WATER.
Fire Fighting Procedures:FIGHT AS A FUEL OIL FIRE.
Unusual Fire/Explosion Hazard:COMBUSTIBLE MATERIAL. AUTOIGNITION TEMP:
>400F.

Spill Release Procedures:SHUT OFF/REMOVE ALL IGNITION SOURCES. EVACUATE
AREA. RECOVER FREE PRODUCT. ADD SAND/EARTH/OTHER SUITABLE
ABSORBENTS. MINIMIZE SKIN CONTACT/BREATHING VAPORS. VENTILATE
CONFINED SPACES. KEEP OUT OF SEWE RS/WATER COURSES BY
DIKING/IMPOUNDING.

Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY
CLOSED/COOL/DRY/AWAY FROM IGNITION SOURCES. USE W/ADEQUATE
VENTILATION.
Other Precautions:ELECTRICALLY GROUND MATERIAL DURING TRANSFER PROCESS.
ALL ELECTRICAL EQUIPMENT IN STORAGE/HANDLING AREA SHOULD BE
INSTALLED PER NFPA REQUIREMENTS. INTENTIONAL MISUSE BY DELIBERATELY
CONCENTRATING & IN HALING PRODUCT MAY BE HARMFUL/FATAL.

Respiratory Protection:WEAR SUPPLIED AIR RESPIRATORY PROTECTION IN
CONFINED/ENCLOSED SPACES.
Ventilation:USE EXPLOSION-PROOF EQUIPMENT SUFFICIENT TO PREVENT
EXCEEDING RECOMMENDED EXPOSURE LIMIT/BUILDUP OF EXPLOSIVE VAPORS.
Protective Gloves:CHEMICAL RESISTANT.
Eye Protection:SPLASH GOGGLES/FACE SHIELD.
Other Protective Equipment:CHEMICAL RESISTANT APRON/OTHER IMPERVIOUS
CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE. NO SMOKING/OPEN LIGHTS. WASH THOROUGHLY AFTER
HANDLING.
Supplemental Safety and Health
HEALTH HAZARDS CONT'D: MODERATE SKIN IRRITATION, DERMATITIS. PETROLEUM
SOLVENTS CAN CAUSE IRRITATION TO NOSE & THROAT, ASPHYXIATION. OTHER
PRECAUTIONS CONT'D: AVOID PROLONGED/REPEATED CONTACT & MINIMI ZE
BREATHING VAPOR/MIST.

Boiling Pt:B.P. Text:300-390F
Vapor Pres: 6
Vapor Density: 3.9
Spec Gravity:<1
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:THICK CONSISTENCY BLACK PASTE W/SLIGHT PETROLEIUM
HYDROCARBON SOLVENT ODOR.
Percent Volatiles by Volume:<35

Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS, LIQUID CHLORINE, CONCENTRATED OXYGEN, SODIUM/CALCIUM
HYPOCHLORITE.
Stability Condition to Avoid:IGNITION SOURCES.
Hazardous Decomposition Products:CO, CO2, NITROGEN OXIDES.

Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. EMPTY CONTAINERS RETAIN RESIDUE & CAN BE DANGEROUS.
DON'T PRESSURIZE/CUT/WELD/BRAZE/SOLDER/DRILL/GRIND/EXPOSE TO
IGNITION SOURCES, THEY MAY EXPLODE. DON'T ATTEMPT TO CLEAN.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.